Luckily the dead engine wasn't dead after all.
Thread Starter
Join Date: Aug 2011
Location: Australia
Posts: 423
Likes: 0
Received 0 Likes
on
0 Posts
Luckily the dead engine wasn't dead after all.
From Subject Received Size Categories
Curt Lewis & Associates, LLC Flight Safety Information [June 23, 2017] [No. 125] Fri 11:27 PM 299 KB
Pilots switch off healthy engine after bird-hit
• A GoAir flight suffered a bird-hit during takeoff at Delhi's IGI airport
• Pilots allegedly turned off the healthy engine which was a wrong decision
• Directorate General of Civil Aviation has grounded both pilots, said a source
NEW DELHI: Over 160 people on a GoAir flight from Delhi to Mumbai on Wednesday had a narrow escape when the aircraft suffered a bird-hit during takeoff at IGI Airport. One of the Airbus A-320's engines ingested the bird during takeoff roll, but instead of switching this engine off as per procedure, the pilots allegedly turned off the healthy one.
"The pilots soon realised their mistake and switched on the healthy engine. The aircraft reached an altitude of about 2,000 feet before it returned to land safely in Delhi. It was a dangerous situation and the Directorate General of Civil Aviation has grounded both pilots. Luckily, the other engine had not failed after the bird-hit and was still powering the plane even after the pilots reportedly switched off the 'healthy' engine, which had not suffered the bird-hit. Otherwise, it would have been bad," said a source.
A GoAir spokesman said: "GoAir flight G8 338 from New Delhi to Mumbai, carrying 155 passengers, suffered a bird-hit on Wednesday. Following standard operating procedure, the aircraft returned to Delhi as a precautionary measure at 11.28am. All passengers were transferred to another aircraft, which was airborne at 1.04pm. The matter is under investigation."
The airline did not comment on the allegedly wrong switching-off of the engine and grounding of the pilots.
Senior commanders said switching off the wrong engine could lead to a disaster. If an engine is damaged for any reason like a bird-hit and the pilots mistakenly switch off the healthy engine too, the aircraft has no working engine.
In February 2015, a Taiwanese airliner (which ceased operations last year) smashed into a highway bridge in Taiwan and then crashed into a river, killing 43 of its 58 passengers, after the pilot turned off the wrong engine.
Pilots switch off healthy engine after bird-hit | Delhi News - Times of India
Curt Lewis & Associates, LLC Flight Safety Information [June 23, 2017] [No. 125] Fri 11:27 PM 299 KB
Pilots switch off healthy engine after bird-hit
• A GoAir flight suffered a bird-hit during takeoff at Delhi's IGI airport
• Pilots allegedly turned off the healthy engine which was a wrong decision
• Directorate General of Civil Aviation has grounded both pilots, said a source
NEW DELHI: Over 160 people on a GoAir flight from Delhi to Mumbai on Wednesday had a narrow escape when the aircraft suffered a bird-hit during takeoff at IGI Airport. One of the Airbus A-320's engines ingested the bird during takeoff roll, but instead of switching this engine off as per procedure, the pilots allegedly turned off the healthy one.
"The pilots soon realised their mistake and switched on the healthy engine. The aircraft reached an altitude of about 2,000 feet before it returned to land safely in Delhi. It was a dangerous situation and the Directorate General of Civil Aviation has grounded both pilots. Luckily, the other engine had not failed after the bird-hit and was still powering the plane even after the pilots reportedly switched off the 'healthy' engine, which had not suffered the bird-hit. Otherwise, it would have been bad," said a source.
A GoAir spokesman said: "GoAir flight G8 338 from New Delhi to Mumbai, carrying 155 passengers, suffered a bird-hit on Wednesday. Following standard operating procedure, the aircraft returned to Delhi as a precautionary measure at 11.28am. All passengers were transferred to another aircraft, which was airborne at 1.04pm. The matter is under investigation."
The airline did not comment on the allegedly wrong switching-off of the engine and grounding of the pilots.
Senior commanders said switching off the wrong engine could lead to a disaster. If an engine is damaged for any reason like a bird-hit and the pilots mistakenly switch off the healthy engine too, the aircraft has no working engine.
In February 2015, a Taiwanese airliner (which ceased operations last year) smashed into a highway bridge in Taiwan and then crashed into a river, killing 43 of its 58 passengers, after the pilot turned off the wrong engine.
Pilots switch off healthy engine after bird-hit | Delhi News - Times of India
Not the first and not the last time. Hopefully they switched on the APU. Sully found out, that this is not a bad idea in any case. On a small prop plane the training to verify the bad engine after TO is rushed, because it creates a lot of drag. On a jet that should be much more relaxed since the bad engine does not create as much drag. As long as there is positive rate of climb there should be no rush and a thorough check from both pilots. So some of the CRM and checklist procedure broke down. Sitting in an armchair it is so easy...
Join Date: Jul 2005
Location: Canadian Shield
Posts: 538
Likes: 0
Received 0 Likes
on
0 Posts
For the next generation of pilots, not a bad time to re-read the British Midland M1 'Kegworth' crash.
https://www.icao.int/safety/airnavig...rways%2092.pdf
https://www.icao.int/safety/airnavig...rways%2092.pdf
If an engine is not on fire and not shaking itself to pieces then why shut it down at all?
If it's giving elec. and hyd. power and can be kept below vibration rpm, keep it running.
If it's giving elec. and hyd. power and can be kept below vibration rpm, keep it running.
Join Date: Aug 2005
Location: London
Posts: 78
Likes: 0
Received 0 Likes
on
0 Posts
One reason (THE reason?) for making the first action of a shutdown procedure 'Thrust Lever - Identify - Close' is that it is the one that is quickly reversible. It's a very good time to consider whether the reaction and outcome is what you would expect. I always thought it worth emphasising in the pre T/O brief.
Join Date: Jan 2008
Location: Denver, CO
Posts: 265
Likes: 0
Received 0 Likes
on
0 Posts
I was thinking this same thing, sort of, from a PAX point of view.
Kegworth was almost understandable -- 737-300 vs. -400, with the change in ducting and the poor gauges on the -300. Trust the smoke rather than the dials.
Glad everything worked out, it's a testament to the flexibility of twins.
Kegworth was almost understandable -- 737-300 vs. -400, with the change in ducting and the poor gauges on the -300. Trust the smoke rather than the dials.
Glad everything worked out, it's a testament to the flexibility of twins.
I wouldn't spend too much time judging what the pilots did based on a news story likely transcribed into English.
For instance I really don't know exactly where they were in the flight regime when they ingested a bird and got symptoms of some sort. Seeing as there was a report that it later was producing power they may have had no more symptoms than a bang followed by a buzz sound.
At the point that they alleged grabbed the wrong throttle they may have been free of symptoms except for the buzz sound. If all they did was pull back the throttle on the unaffected engine to idle or greater, the buzz sound on the damaged engine would continue and so would its thrust. At that point they may have simply advanced the undamaged engines thrust and made an airturnback having sorted out the correct response.
For instance I really don't know exactly where they were in the flight regime when they ingested a bird and got symptoms of some sort. Seeing as there was a report that it later was producing power they may have had no more symptoms than a bang followed by a buzz sound.
At the point that they alleged grabbed the wrong throttle they may have been free of symptoms except for the buzz sound. If all they did was pull back the throttle on the unaffected engine to idle or greater, the buzz sound on the damaged engine would continue and so would its thrust. At that point they may have simply advanced the undamaged engines thrust and made an airturnback having sorted out the correct response.
......the pilots allegedly turned off the healthy one.
"The pilots soon realised their mistake and switched on the healthy engine.
"The pilots soon realised their mistake and switched on the healthy engine.
Join Date: Jun 2013
Location: Or-E-Gun, USA
Posts: 326
Likes: 0
Received 0 Likes
on
0 Posts
It has happened before - and it will happen again. Other then extreme caution and verification by both pilots, what else can be done? Verify = and verify again/ This should NOT Happen, but it will. Close call!!
Join Date: Jun 2017
Location: Florida
Posts: 2
Likes: 0
Received 0 Likes
on
0 Posts
Really.
It takes some effort to shut down the wrong engine on an A320 when the ECAM literally tells you what to do!
Given it hadn't actually failed I can only imagine they didn't get an ECAM caution/warning and instead were working off the vibration indicator or something on the EWD and in the heat of the moment failed to agree and confirm the right engine.
It takes some effort to shut down the wrong engine on an A320 when the ECAM literally tells you what to do!
Given it hadn't actually failed I can only imagine they didn't get an ECAM caution/warning and instead were working off the vibration indicator or something on the EWD and in the heat of the moment failed to agree and confirm the right engine.
Join Date: Feb 2008
Location: Wingham NSW Australia
Age: 83
Posts: 1,343
Likes: 0
Received 0 Likes
on
0 Posts
Trust the smoke, rather than the dials.
I was thinking this same thing, sort of, from a PAX point of view.
Kegworth was almost understandable -- 737-300 vs. -400, with the change in ducting and the poor gauges on the -300. Trust the smoke rather than the dials.
Glad everything worked out, it's a testament to the flexibility of twins.
Kegworth was almost understandable -- 737-300 vs. -400, with the change in ducting and the poor gauges on the -300. Trust the smoke rather than the dials.
Glad everything worked out, it's a testament to the flexibility of twins.
Only half a speed-brake
Picked an OEI technique some time ago in the SIM from a colleague. One was quite ashamed of not being trained to do so earlier, nor devising it on my own.
N1TLA.JPG
a) As the trust-lever is moved to idle, as a part of the shut-down drill, focus the eyes on the TL position indicator (white doughnut on the picture above). Observe its movement on the correct engine.
b) move the TL slowly, watching with your other eye the good engine's N1 - that they do NOT move, with sharp ears and sensitive pants towards any undesired change.
It is easily done with a two-phased movement: retard to 2/3rds, check the gauges and gut, if all ok then close the TL all the way.
c) do not let go of the retarded TL straight away, pause for one deep breath with the eyes on the instruments.
Rush is the ultimate killer. Tenerife, Spanair, Taipei, sadly many others.
N1TLA.JPG
a) As the trust-lever is moved to idle, as a part of the shut-down drill, focus the eyes on the TL position indicator (white doughnut on the picture above). Observe its movement on the correct engine.
b) move the TL slowly, watching with your other eye the good engine's N1 - that they do NOT move, with sharp ears and sensitive pants towards any undesired change.
It is easily done with a two-phased movement: retard to 2/3rds, check the gauges and gut, if all ok then close the TL all the way.
c) do not let go of the retarded TL straight away, pause for one deep breath with the eyes on the instruments.
Rush is the ultimate killer. Tenerife, Spanair, Taipei, sadly many others.
Last edited by FlightDetent; 19th Jul 2017 at 10:48.
Join Date: Feb 2015
Location: UK
Posts: 35
Likes: 0
Received 0 Likes
on
0 Posts
From Flight Global website 5th February 2019
"Once airborne the first officer “misinterpreted” the N1 speed reading of the right-hand engine as a vibration of the left-hand engine, the inquiry states.
The first officer called out a beyond-limit vibration of the unaffected left-hand engine and, as a result of the incorrect assessment, the left-hand engine was incorrectly shut down around 30s after rotation.
Thrust of the problematic right-hand engine was increased and the aircraft was left to climb on this engine alone for over 3min.
The first officer, says the inquiry, “repeatedly” advised the captain, incorrectly, that the left-hand engine was experiencing out-of-limit vibration."
I would post the full link but I'm more of a lurker and haven't posted enough times yet to be allowed to post a link.
I know its a pressure situation, but identifying the wrong engine for shutdown when the instrumentation clearly identified the correct engine is a bad error.
How can high vibration indications be made clearer to avoid mis-reading which engine has suffered damage? I'm not familiar with the cockpit display in the 737, presumable its graphical rather than spell out "HIGH VIBS LEFT" ?
"Once airborne the first officer “misinterpreted” the N1 speed reading of the right-hand engine as a vibration of the left-hand engine, the inquiry states.
The first officer called out a beyond-limit vibration of the unaffected left-hand engine and, as a result of the incorrect assessment, the left-hand engine was incorrectly shut down around 30s after rotation.
Thrust of the problematic right-hand engine was increased and the aircraft was left to climb on this engine alone for over 3min.
The first officer, says the inquiry, “repeatedly” advised the captain, incorrectly, that the left-hand engine was experiencing out-of-limit vibration."
I would post the full link but I'm more of a lurker and haven't posted enough times yet to be allowed to post a link.
I know its a pressure situation, but identifying the wrong engine for shutdown when the instrumentation clearly identified the correct engine is a bad error.
How can high vibration indications be made clearer to avoid mis-reading which engine has suffered damage? I'm not familiar with the cockpit display in the 737, presumable its graphical rather than spell out "HIGH VIBS LEFT" ?
I'm not familiar with the cockpit display in the 737, presumable its graphical rather than spell out "HIGH VIBS LEFT" ?
0.0 — VIB N1 — 0.0
0.0 — ......N2 — 0.0
... and it did occur to me that in a rush, or lacking experience with a VIB indication (or one's morning coffee), the brain could read
0.0 — VIB N1 — 3.6
as "(Engine) N(umber) 1, Vibration 3.6"
Not an excuse, possibly a reason.
Join Date: Jun 2012
Location: FRA
Age: 36
Posts: 13
Likes: 0
Received 0 Likes
on
0 Posts
The VIB display (according to picture at Aviation Herald looks like
0.0 — VIB N1 — 0.0
0.0 — ......N2 — 0.0
... and it did occur to me that in a rush, or lacking experience with a VIB indication (or one's morning coffee), the brain could read
0.0 — VIB N1 — 3.6
as "(Engine) N(umber) 1, Vibration 3.6"
Not an excuse, possibly a reason.
0.0 — VIB N1 — 0.0
0.0 — ......N2 — 0.0
... and it did occur to me that in a rush, or lacking experience with a VIB indication (or one's morning coffee), the brain could read
0.0 — VIB N1 — 3.6
as "(Engine) N(umber) 1, Vibration 3.6"
Not an excuse, possibly a reason.
My thought exactly! And the most propable scenario in my opinion.
They could redesign it to read NL (low) and NH (high) instead. But then again you´ll have folks reading N-"left" when under stress...
From what I read the Captain PF and 20000 hrs and the First Officer PM less than 1000 made a mistake and got all safely on the ground.... well done
The worry for me is that the flight crew then took the replacement aircraft and landed no more than 4 hrs behind schedule
WTF no one grounded them immediately while investigating what happened
The worry for me is that the flight crew then took the replacement aircraft and landed no more than 4 hrs behind schedule
WTF no one grounded them immediately while investigating what happened
Join Date: Sep 1998
Location: wherever
Age: 55
Posts: 1,616
Likes: 0
Received 0 Likes
on
0 Posts
Why the rush to shut down engines. If it's vibrating it's vibrating. Wait until everything else is sorted then both of you take your time to identify the problem. Wait long enough and it will resolve itself!