Go Back  PPRuNe Forums > Aircrew Forums > Freight Dogs
Reload this Page >

Hercules Military and civy differences.

Freight Dogs Finally a forum for those midnight prowler types who utilise the unglamorous parts of airports that many of us never get to see. Freight Dogs is for pilots and crew who operate mostly without SLF.

Hercules Military and civy differences.

Old 20th Aug 2008, 14:52
  #1 (permalink)  
Thread Starter
 
Join Date: Feb 2006
Location: Sausageside
Posts: 51
Likes: 0
Received 0 Likes on 0 Posts
Hercules Military and civy differences.

Can anyone list the main differences between the military and civy versions of the mighty Hercky bird? Why did they never appear on the G-reg?
fastener is offline  
Old 20th Aug 2008, 15:05
  #2 (permalink)  
 
Join Date: Feb 2005
Location: North Wales
Posts: 50
Likes: 0
Received 0 Likes on 0 Posts
Two main reasons why the C-130 was never accepted on the UK register....First it did not have a stick shaker and second it only had 2 fire bottles....CAA required one bottle per engine
Nippon1 is offline  
Old 20th Aug 2008, 20:11
  #3 (permalink)  
 
Join Date: Mar 2000
Location: Arizona USA
Posts: 8,571
Likes: 0
Received 0 Likes on 0 Posts
Two main reasons why the C-130 was never accepted on the UK register....First it did not have a stick shaker and second it only had 2 fire bottles....CAA required one bottle per engine
One quite possible other consideration...wing box carry-through structure...not ideal, from a civil standpoint.

UKCAA...right on this one.
411A is offline  
Old 21st Aug 2008, 05:45
  #4 (permalink)  
Thread Starter
 
Join Date: Feb 2006
Location: Sausageside
Posts: 51
Likes: 0
Received 0 Likes on 0 Posts
Many thanks guys.
fastener is offline  
Old 21st Aug 2008, 09:38
  #5 (permalink)  
 
Join Date: Nov 2000
Posts: 645
Likes: 0
Received 0 Likes on 0 Posts
Brits had Belfasts.
Kerosene Kraut is offline  
Old 21st Aug 2008, 21:55
  #6 (permalink)  
 
Join Date: Jun 2007
Location: In this very moment of a short life.
Posts: 180
Likes: 0
Received 0 Likes on 0 Posts
I believe that the Hyd system on the C 130 has no redundancy.......................a very dangerous machine all round. I loved jumping from them though during many nite time ops.
Siguarda al fine is offline  
Old 21st Aug 2008, 23:28
  #7 (permalink)  
 
Join Date: Oct 2006
Location: usa
Posts: 29
Likes: 0
Received 0 Likes on 0 Posts
Neither does the 747 but still a very safe machine as is the Herc.
Not a better airplane in the world for what it does.
Lowrider2 is offline  
Old 21st Aug 2008, 23:35
  #8 (permalink)  
 
Join Date: May 2005
Location: nocte volant
Posts: 1,114
Received 0 Likes on 0 Posts
I believe that the Hyd system on the C 130 has no redundancy
True, a couple of years ago I was an AD on a RAAF H model departing Richmond when we suffered a burst hydraulic line shortly after t/o. The pilots turned 180 Deg and landed on the same runway. Total time airbourne was less than a minute but shortly after touchdown control of all hydraulic control surfaces was lost.(so one of the pilots told me)
Trojan1981 is offline  
Old 22nd Aug 2008, 01:34
  #9 (permalink)  
 
Join Date: Sep 2005
Location: england
Posts: 385
Likes: 0
Received 0 Likes on 0 Posts
I believe that the Hyd system on the C 130 has no redundancy.......................a very dangerous machine all round. I loved jumping from them though during many nite time ops.

That is possibly the most stupid comment I have ever heard ... I have been working and flying on Hercs for the last 9 years, If anything has system redundancy the Hercules has... 2 completely seperate duel hydrualic systems for the primary flying controls, then manual reversion, the utility system has full mechanical over-ride should the electrics fail, so you can still get the flaps and gear down, and also have manual wind-down for the flaps and landing gear. If it STILL dosn't work you can free fall the gear, and if it STILL dosn't work you can disconnect the screwjacks and allow the gear to fall under it's own weight....

The aircraft can fly on one engine at a push, and will work with zero power, as the engines are fully mechanical. So I think I would rarther be on a Herc than any other aircraft in dire straights.
Kengineer-130 is offline  
Old 22nd Aug 2008, 06:21
  #10 (permalink)  
Thread Starter
 
Join Date: Feb 2006
Location: Sausageside
Posts: 51
Likes: 0
Received 0 Likes on 0 Posts
Hydraulic system sounds similar to the L-188 Electra. Hey, Dire Straights.....that would be a good name for a rock band.
fastener is offline  
Old 22nd Aug 2008, 15:19
  #11 (permalink)  
 
Join Date: Apr 2008
Location: nowhere
Posts: 1
Likes: 0
Received 0 Likes on 0 Posts
Originally Posted by Kengineer-130
That is possibly the most stupid comment I have ever heard ... I have been working and flying on Hercs for the last 9 years, If anything has system redundancy the Hercules has... 2 completely seperate duel hydrualic systems for the primary flying controls, then manual reversion, the utility system has full mechanical over-ride should the electrics fail, so you can still get the flaps and gear down, and also have manual wind-down for the flaps and landing gear. If it STILL dosn't work you can free fall the gear, and if it STILL dosn't work you can disconnect the screwjacks and allow the gear to fall under it's own weight....

The aircraft can fly on one engine at a push, and will work with zero power, as the engines are fully mechanical. So I think I would rarther be on a Herc than any other aircraft in dire straights.
Perhaps your Herc's are different than the civil ones I flew. Manual reversion? Our books said never to simulate loss of hydraulic boost assistance as it could result in "an unusual attitude and requirements for high manual forces to move the flight controls". Also, "Greatly increased forces will be required to move a control for which hydraulic assistance has been turned off"(such as after a booster assembly having failed in a hardover).

These examples are where you still have the hydraulic fluid in the lines but little or no hydraulic power available. When parked, try moving the flight controls on the ground with only the hydraulic suction boost pumps on and then with no hydraulic power at all. The first is not easy, the second is extremely difficult at best. Now imagine trying to do that with airflow over the flight controls...good luck.

Then there is the loss of all hydraulic fluid from your two independent hydraulic systems that power each flight control system for redundency. Unlikely situation perhaps, but there have been several Hercs that have thrown props that went in one side of the fuselage and out the other damaging other engines and hydraulic systems. As well, military operations increase the risk of this situation occuring. I am not aware of any mechanical backup to operate the flight controls(manual reversion).

So what to do? According to the book, use your electrically operated trim tabs and engine power with inboard engines(that blow air over the tail) for pitch control and outboards for speed control. Worked somewhat well in the sim on the several attempts that I tried it.....for a while, after finally gaining control. Usually I could get set up on approach. But at some point, each time I tried it, control would eventually be lost and I crashed. Perhaps this particular sim is different than other sims and for sure the airplane flies much better in real life but I sure wouldn't want to try landing after a complete hydraulic loss.

Personally, I thought Lockheed's hydraulic system design was poor. The gear, flaps, nosewheel steering and normal braking system(the one with anti-skid) are on the same hydraulic system(utility) which was run by engines 1 and 2. So when these two engines fail(and they always seemed to in the sim), you lose all these functions. So the gear has to be manually extended which may take a long time, the flaps have to be manually cranked down into the airflow with muscle power if you decide to use them and not more than 50%(That will probably take a long time as well but I have never talked to anyone who has done it). If you are fortunate and not too heavy and your second shutdown on the left wing gives you enough time, you can extend the gear and some flap while you still have that hydraulic system available. In the sim, we were always fortunate in terms of weight, altitude, temperature, runway length availability and time availability before shutting down the second engine. We would only extend the flaps to 20% allowing some flap with minimal drag plus increased rudder boost. So now we are landing with hardly any flap, high approach speed, no reverse capability(due to asymmetry) and no anti-skid. Why didn't they put at least one of these systems on the other(Booster) hydraulic system. Lockheed logic we called it.

On a separate subject but speaking about the main gear, there is no guarantee as far as I know that a gear will extend on their own, as preferred during a manual extension. Perhaps the screwjacks are dirtier than they should be and that is not unusual for typical herc ops. Or something such as a rag could be the problem, after all, that is what maintenance cleaned the screwjacks with so your gear would hopefully extend by themselves after pulling the big handle to release them. The alternative, 600 turns of the crank if a full manual extension is required. How much fuel did you say we have left?

So now you find out that you need to do an emergency gear extension on one of the main gears by disconnecting the screwjacks because the gear is so jammed. Special tools in a metal box riveted shut(so the tools don't mysteriously disappear on you over the yaers) are required. Somehow you have to smash the box open then spend however long it takes to disconnect the the screwjacks so the gear will freefall down. Remember to disconnect the bolts in the proper order or you may lose your hands in the process. And you won't be able to even attempt this if you have a heavy piece of cargo right near the gear area that doesn't allow access to the panels to do all this. After all, the plane was designed among other things, to carry cargo. As you can see in this C-130 gear up landing report, it took 30 minutes for the F/E and loadmaster to undo only two nuts in their failed emergency extension attempt.

200000618

Easily flying on one engine? Depends on a lot of things I'm sure.


As 411A mentioned, no stick shaker. In fact no artificial stall warning at all, however there was plenty of natural stall warning buffet. But no certification in the U.K.because it didn't have one fire bottle per engine? Neither does a 727.

Last edited by JammedStab; 23rd Aug 2008 at 11:57.
JammedStab is offline  
Old 28th Aug 2008, 01:14
  #12 (permalink)  
 
Join Date: Aug 2006
Location: Klamath Falls, OR
Age: 65
Posts: 28
Likes: 0
Received 0 Likes on 0 Posts
Know what your talking about!

First of all the airplane won't fly on one engine, unless it is almost totally empty. Second, the C-130 has been flown by every "free nation" in the world (verbage "free world" as of the 1990's) and by the 90's had one of the best safety records of any aircraft. Second, it has three hydraulic systems; two of which (utility and booster) power the flight controls separately. Yes, you train in the simulator with a totally failed hydraulics; but, it is a confidence manuever , designed to show you the airplane is stable and will land if you don't over control and follow "instructions". Just because the Britts don't certify it for passenger operations; doesn't mean squat! The last C-130 out of South Viet Nam, had 400 people crammed in it (it's parked at the front gate of Little Rock AFB, Arkansas), and was probably getting shot at as it left. It's basically a 250 kt, straight wing cessna! It doesn't need a stick shaker, as you'd have to be doing something stupid to stall it, even in the terminal approach area.

Randall "RP" Bancroft
Former Marine/Air National Guard C-130 Instructor/Pilot

Last edited by cpnkirk59; 28th Aug 2008 at 01:17. Reason: Stick shaker addressed
cpnkirk59 is offline  
Old 29th Aug 2008, 07:07
  #13 (permalink)  
 
Join Date: Feb 2008
Location: Wingham NSW Australia
Age: 83
Posts: 1,343
Likes: 0
Received 0 Likes on 0 Posts
Hercules - A Lockheed Legend

Geez I must have been fortunate. I spent eight years as a F/E on Hercules (A-E & H models) and never, and I mean never, suffered double assymetric engine failure, total loss of hydraulic or electrical systems etc etc. Sure, the C130 hydraulic systems are not perfect, however they are generally reliable, and the flight controls may be moved manually, albiet with great effort required. The biggest problem the Brits had was they used Vickers engine driven pumps. As for no redundancy, that statement is just plain wrong. Two individual systems supply flight control boost pressure, they being the Utility system and the Booster System. The Hercules has been in service for more than 50 years and is still in production in the latest variant. No aircraft I am aware of has the capacity to perform the variety of tasks which the Hercules has done over the years. The C130 surely is a "Legend in it's own lifetime".
Old Fella is offline  
Old 29th Aug 2008, 08:03
  #14 (permalink)  
 
Join Date: Oct 2006
Location: N51 09".94 W001 45".51
Posts: 160
Likes: 0
Received 0 Likes on 0 Posts
There is a whole lot of rubbish on this thread from people who have obviously have never been near albert ! I have worked on them for 15 years and covered most of the planet. The hyd systems (all 3) are fine you have old fashioned flying control cables so you can fly without them ! The CAA dont like no stick shaker and lack of anti icing all the way up the fin as far as i know. As for differences between civvy and military that depends on what model really. Civvy hercs do not have para doors other wise not a lot. By the way the J model has a stick shaker and de icer boot on the fin. Long live Albert
billynospares is offline  
Old 29th Aug 2008, 13:33
  #15 (permalink)  
 
Join Date: Apr 2004
Location: Erehwon
Posts: 1,146
Likes: 0
Received 0 Likes on 0 Posts
I believe one of the key differences is that fewer people shoot at the civvy one.

Could be wrong though . . . (all the guys on Safair no doubt are shouting - YOU ARE!)

Military ones are also painted more interesting colours:

RAF in mid 70's, two tone brown and black underneath - operating in Western Europe tactically.

Aha lets paint them grey and green - yes you guessed, now send them into the Gulf (again).

Operating in desert environment so let's paint them light blue or even dark green (all over). Logic appears to be, you've got to give the locals SOMETHING to aim at, like the 'shoot me here' white crosses in Ethiopia (bullet just missed LOX converter).

See what I mean? - Now you can see why there's no Government Surplus paint available anymore - it's all in Cambridge!
Dengue_Dude is offline  
Old 29th Aug 2008, 14:28
  #16 (permalink)  
 
Join Date: Jan 2005
Location: The Green Heart of Europe!
Age: 65
Posts: 235
Received 0 Likes on 0 Posts
ABSOLUTELY wrong! And not just the SAFAIR guys!
CargoMatatu is offline  
Old 30th Aug 2008, 20:29
  #17 (permalink)  
 
Join Date: Aug 2008
Location: Canada
Posts: 48
Likes: 0
Received 0 Likes on 0 Posts
Two main reasons why the C-130 was never accepted on the UK register....First it did not have a stick shaker and second it only had 2 fire bottles....CAA required one bottle per engine

So the 727 was never aloud on the UK register either?? (2 Bottles 3 Engine)
ScudRunner08 is offline  
Old 31st Aug 2008, 12:51
  #18 (permalink)  
 
Join Date: Jul 2008
Location: UK
Posts: 6
Likes: 0
Received 0 Likes on 0 Posts
The L-188 Electra doesn't have a stick shaker either. There are six of them flying on the UK register.

There's a piece of recent cockpit video on youtube that shows why one isn't needed! Sorry - don't have the link though.

J
John1984 is offline  
Old 31st Aug 2008, 21:03
  #19 (permalink)  
 
Join Date: Nov 2004
Location: Here, there & everywhere
Posts: 100
Likes: 0
Received 0 Likes on 0 Posts
I saw an all white Herc early yesterday afternoon at about 8 to 10,000 ft heading south above West Sussex. I got the bins out as I did'nt know what the wonderful noise was coming from. Presumably it was a civvie one ?
Northern Hero is offline  
Old 1st Sep 2008, 03:17
  #20 (permalink)  
 
Join Date: Jun 2008
Location: Texas
Age: 42
Posts: 1
Likes: 0
Received 0 Likes on 0 Posts
The L-100 doesn't have the pilots' kick windows. Minor, but it's a difference. As a herk pilot, the plane is awesome, although it's getting old. The plane is very safe and rugged.
polcat is offline  

Thread Tools
Search this Thread

Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

Copyright © 2024 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.