Go Back  PPRuNe Forums > Aircrew Forums > Military Aviation
Reload this Page >

F-35 Cancelled, then what ?

Military Aviation A forum for the professionals who fly military hardware. Also for the backroom boys and girls who support the flying and maintain the equipment, and without whom nothing would ever leave the ground. All armies, navies and air forces of the world equally welcome here.

F-35 Cancelled, then what ?

Old 14th Jun 2019, 07:44
  #11901 (permalink)  
 
Join Date: Sep 2004
Location: Royal Berkshire
Posts: 1,724
Received 76 Likes on 38 Posts
Originally Posted by ORAC
The link below leads to a long list of articles posted yesterday explicating various issues. I’ve chosen just one to post separately to give an example......

http://www.defensenews.com/smr/hidden-troubles-f35/

The Hidden Troubles of the F-35

https://www.defensenews.com/air/2019...-environments/

The Marine Corps’ ‘No. 1 priority’ for the F-35 involves a rough landing in hot environments

WASHINGTON — It was a hot day aboard the amphibious assault ship Essex when a pilot brought his F-35B in for what is known as a “mode four” flight operation, where the jet enters hover mode near a landing spot, slides over to the target area and then vertically lands onto the ship.

It’s a key part of the F-35B’s short-takeoff-and-vertical-landing capability, known as STOVL. And normally, everything in a “mode four” landing goes smoothly. But on this day, when the pilot triggered the thrust to slow his descent, something went wrong. The engine, working hard on a day that temperatures cracked 90 degrees Fahrenheit while trying to lift a plane that was heavier than most returning to base, wouldn’t generate the needed thrust for a safe, ideal landing.

The pilot got the plane down, but was shaken enough by the situation to write up an incident report that would eventually be marked as “high” concern by the F-35 program office. “May result in unanticipated and uncontrolled sink, leading to hard landing or potential ejection/loss of aircraft, particularly in the presence of HGI [hot gas ingestion],” reads a summary of the issue, which was obtained by Defense News as part of a cache of “for official use only” documents that detail major concerns with the F-35 Joint Strike Fighter.....

The issue seems to stem from two factors: the heat, and the fact that much of the testing for the “mode four” maneuver was done with planes that were lighter, as they weren’t armed with heavy stores of weaponry. Feedback from the Marine Corps highlighted that while the average engine should not see this issue until around 750 flight hours, “several engines are at/near the point of concern,” and that number will continue to grow with the extended use of older planes.........

Winter said engineers have identified an issue in the design of the control software that the pilot uses to generate demand for thrust from the propulsion system.

“There’s no redesign of the engine [necessary]. The engine is doing what the engine is supposed to do,” Winter emphasized, before acknowledging that in addition to the software fix, the program office has worked with Honeywell to change how the company calibrates the throttle valve on the engine. “We’ve identified the software fix for the control system, the calibration fix to the throttle valve and some near-term fleet actions that could be taken for very hot days to ensure that the pilot gets the performance he or she needs on those hot days,” he said.

That software fix will be a rolling target, as the first increment of the software release is due in June, followed by another at the end of this year or early next year. “We’ve given them tighter tolerances to tune them more precisely, so that when it goes on the engine it’s no longer not giving the command the way it’s supposed to be,” Winter explained. “It wasn’t tuned correctly for this high-demand phase of flight. Now, we fixed that. That’s fixed. The software is going in to make sure that the pilot can command that thrust and understand the heat and the loading.”

Those fixes won’t be cheap, and when asked who would pay for them, Winter was blunt, saying it is his office’s belief the thrust issue is a “design deficiency” that merits “consideration” from industry. “In this case it doesn’t matter that the design was done back in 2002, it’s still pragmatistic, so you owe consideration because we’re fixing it right now,” Winter said of industry..........
Err.........I maybe being a bit thick here, but isn't this 'problem' why UK is going down the SRVL route for B ops.....??

GeeRam is offline  
Old 14th Jun 2019, 13:47
  #11902 (permalink)  
 
Join Date: Jul 2006
Location: The back of beyond
Posts: 2,118
Received 151 Likes on 77 Posts
Originally Posted by GeeRam
Err.........I maybe being a bit thick here, but isn't this 'problem' why UK is going down the SRVL route for B ops.....??
As far as I am aware, SRVL was intended to enhance the aircraft's performance rather than to mitigate any problems.
melmothtw is offline  
Old 14th Jun 2019, 14:14
  #11903 (permalink)  
Below the Glidepath - not correcting
 
Join Date: Jun 2005
Location: U.S.A.
Posts: 1,874
Received 60 Likes on 18 Posts
and the fact that much of the testing for the “mode four” maneuver was done with planes that were lighter, as they weren’t armed with heavy stores of weaponry.
I had no idea you could perform trials and Release to Service testing in a more benign environment than is likely to be encountered by operational users. Must be a new thing...
Two's in is offline  
Old 14th Jun 2019, 17:14
  #11904 (permalink)  
 
Join Date: Jun 2006
Location: 350/3 Compton
Age: 76
Posts: 777
Received 352 Likes on 86 Posts
A quick shufti at the JPT gauge should sort that problem; JPT too high - burn some gas off. In the old days the duty pilot would calculate the max VL fuel weight for the worst engine and post it on the board. Individual pilots would then confirm their own limits on the VSTOL computer (wizz-wheel).

A free-air hover can be attained at a greater gross weight than a VL. SRVL increases the bring-back weight by allowing the wing to develop some lift (a bit) and reducing hot gas recirculation into the intake close to the deck.

Can't be that difficult.

mog

BTW, 37 years ago today the Falkland Islands were liberated, thanks in no small measure to the Sea Harrier. BZ guys.

Mogwi is offline  
Old 14th Jun 2019, 18:15
  #11905 (permalink)  
 
Join Date: Jul 2013
Location: Everett, WA
Age: 68
Posts: 4,356
Received 157 Likes on 75 Posts
Educated guess here, but it sounds to me like it the engine became EGT limited and cut back thrust unexpectedly.
Assuming that's correct (or at least close), the 'fix' would be easy - get rid of EGT limiting except during starting. We did that in the commercial world 35 years ago, assuming that the pilot is in a better position to judge if they need to exceed the EGT limit for safety reasons than the FADEC was.
tdracer is offline  
Old 15th Jun 2019, 13:27
  #11906 (permalink)  
 
Join Date: Dec 2018
Location: Dundee
Posts: 2
Likes: 0
Received 0 Likes on 0 Posts
Originally Posted by Two's in
I had no idea you could perform trials and Release to Service testing in a more benign environment than is likely to be encountered by operational users. Must be a new thing...
"the fact that much of the testing for the “mode four” maneuver was done with planes that were lighter, as they weren’t armed with heavy stores of weaponry. "

I believe there was a large amount of crowing about the skips ability to return to deck with unexpended ordinance..
weemonkey is offline  
Old 15th Jun 2019, 13:41
  #11907 (permalink)  
 
Join Date: Jul 2009
Location: The sunny South
Posts: 819
Received 0 Likes on 0 Posts
Originally Posted by weemonkey
"the fact that much of the testing for the “mode four” maneuver was done with planes that were lighter, as they weren’t armed with heavy stores of weaponry. "

I believe there was a large amount of crowing about the skips ability to return to deck with unexpended ordinance..
Yes. That's when SRVL (Shipborne Rolling Vertical Landing) would come into its own rather than a purely vertical landing. By the sound of it, this trial was conducted using the latter.
FODPlod is offline  
Old 15th Jun 2019, 16:03
  #11908 (permalink)  
 
Join Date: Dec 2010
Location: Middle America
Age: 84
Posts: 1,167
Likes: 0
Received 0 Likes on 0 Posts
Originally posted by tdracer
Educated guess here, but it sounds to me like it the engine became EGT limited and cut back thrust unexpectedly.
I'm not sure about the turbine temperature control architecture used on F135 engines, but in some other military engines like the F101 or F110, EGT isn't used to control turbine temperature upper limits. In military engines, there is less turbine temperature margins when operating on a normal fan speed schedule. To protect the high pressure turbine from excessive over temperature the control system incorporates a turbine blade temperature limiting function known as T4B. A dedicated optical infrared pyrometer is used to measure the temperature of the HPT turbine blade. This signal is fed to the electronic control which reduces core fuel flow to limit the turbine temperature. T4B anticipation logic is built in to prevent excessive overshoots during power bursts.
Turbine D is offline  
Old 16th Jun 2019, 04:14
  #11909 (permalink)  
 
Join Date: Jul 2013
Location: Everett, WA
Age: 68
Posts: 4,356
Received 157 Likes on 75 Posts
Originally Posted by Turbine D
I'm not sure about the turbine temperature control architecture used on F135 engines, but in some other military engines like the F101 or F110, EGT isn't used to control turbine temperature upper limits. In military engines, there is less turbine temperature margins when operating on a normal fan speed schedule. To protect the high pressure turbine from excessive over temperature the control system incorporates a turbine blade temperature limiting function known as T4B. A dedicated optical infrared pyrometer is used to measure the temperature of the HPT turbine blade. This signal is fed to the electronic control which reduces core fuel flow to limit the turbine temperature. T4B anticipation logic is built in to prevent excessive overshoots during power bursts.
GE tried to use that pyrometer trick on the GE90-94B - didn't work as well in the commercial environment as it did on the military and they went back to a thermocouple based system on the GE90-115B (and GEnx). However my point remains, pulling back thrust to protect turbine temps caused us big problems in commercial (it didn't help that Pratt had a POS wire harness that would short and indicate very high EGT causing the control to pull back thrust during takeoff). So we did away with EGT limiting except during autostart - counting on the pilot to pull back power if there was an exceedance and it wasn't an emergency.
tdracer is offline  
Old 16th Jun 2019, 15:04
  #11910 (permalink)  
 
Join Date: Jan 2014
Location: Norfolk
Posts: 428
Likes: 0
Received 0 Likes on 0 Posts
The RB199 in the Tornado was one of the first to use optical pyrometers to record and control EGT. They were more accurate than conventional downstream thermocouples but they were much higher maintenance because of the tendency to soot up. They were supposed to be cleaned every 25 hrs, calibrated every 50 hours and performance tested every 100 hrs. The 25 hr cleans were frequently "cuffed off" but you can see why such a regime would be prohibitive for civilian applications. I've not really kept up with the civilian engine sector over the past 15 years and I'd be interested to know if any modern civvy turbofan uses pyrometers.
Vendee is offline  
Old 17th Jun 2019, 18:45
  #11911 (permalink)  
 
Join Date: Jul 2013
Location: Everett, WA
Age: 68
Posts: 4,356
Received 157 Likes on 75 Posts
I've not really kept up with the civilian engine sector over the past 15 years and I'd be interested to know if any modern civvy turbofan uses pyrometers.
Not 100% positive about this, but I believe GE still uses the pyrometer system on the GE90-94B - not bothering to retrofit to the -1115B style EGT. Granted I don't think the GE90-94B is still in production having be superseded by the -115B.
The GE90-94B was a pretty lousy engine out of the box (unreliable and high maintenance), but matured very nicely providing the basis for the -115B.
tdracer is offline  
Old 17th Jun 2019, 22:36
  #11912 (permalink)  
 
Join Date: Jan 2003
Location: Leicestershire, England
Posts: 1,170
Likes: 0
Received 0 Likes on 0 Posts
F-35 display, from the cockpit...

Some nice footage from the cockpit of an F-35A during a display over Miami Beach during the Hyundai Air & Sea Show May 26, 2019.

Rhino power is offline  
Old 18th Jun 2019, 05:31
  #11913 (permalink)  
 
Join Date: Nov 2018
Location: back out to Grasse
Posts: 557
Received 28 Likes on 12 Posts
Just an uninformed comment but I would assume from looking at the video that an override to the control software permits a robust pull to the wrong edge of the buffet, not to mention the pedal turn. Perhaps it's just a result of the camera being set on a flexible mounting.

IG
Imagegear is offline  
Old 20th Jun 2019, 06:28
  #11914 (permalink)  
 
Join Date: Dec 2017
Location: australia
Posts: 389
Received 28 Likes on 17 Posts
If it was a solid mount, you wouldn't see any movement, other than the pilot. So there is a bit of both. There is some buffet apparent, airflow boundary layer, laminar flow and all that stuff. The video seems to make it out to be a lot more than it actually is.

Last edited by golder; 20th Jun 2019 at 06:40.
golder is online now  
Old 20th Jun 2019, 15:08
  #11915 (permalink)  
 
Join Date: Dec 2009
Location: Welwyn Garden City
Age: 63
Posts: 1,851
Received 77 Likes on 43 Posts
https://www.defensenews.com/smr/hidden-troubles-f35/2019/06/12/when-us-navy-and-marine-f-35-pilots-most-need-performance-the-aircraft-becomes-erratic/

See
the info on the link above, not very reassuring regarding Bs and Cs.

Best regards,

FB
Finningley Boy is offline  
Old 20th Jun 2019, 15:47
  #11916 (permalink)  

 
Join Date: Jan 2003
Location: Bourton-on-the-Water
Posts: 1,017
Received 16 Likes on 7 Posts
In that video - thanks Rhino power, btw, I enjoyed it - but why is the pilot using both hands on the stick at one stage? Anyone know?

airsound
airsound is offline  
Old 20th Jun 2019, 16:50
  #11917 (permalink)  
 
Join Date: Apr 2005
Location: UK
Posts: 2,164
Received 46 Likes on 22 Posts
Presumably to push the aircraft outside the normal control law limits and hold the pitch and roll at that level for the pedal turn.
Just This Once... is offline  
Old 21st Jun 2019, 07:22
  #11918 (permalink)  
Ecce Homo! Loquitur...
 
Join Date: Jul 2000
Location: Peripatetic
Posts: 17,228
Received 1,496 Likes on 678 Posts
Just a shame if you operate the F35B........

http://aviationweek.com/defense/lock...-upgrade-f-35a

Lockheed Martin Proposes 40% Fuel Capacity Upgrade for F-35A

Lockheed Martin has started engineering studies focused on substantially extending the range of the F-35A by increasing the total onboard fuel capacity by 40% and improving the aircraft’s fuel efficiency, Aviation Week has learned.

The studies would resurrect a long-abandoned plan to install external fuel tanks under the wings of the conventional takeoff-and-landing variant. The range-extension study also could benefit from proposed propulsion improvements, such as Pratt & Whitney’s Growth Option upgrade offer for the F135 engine........

Not all customers wanted to rely on the range provided by internal fuel capacity alone, though. When the U.S. State Department approved the Israeli export configuration in 2011, the F-35I included external fuel tanks. But the impact on the cost and schedule for the aircraft forced Israeli officials to defer the requirement.

Nonetheless, work continued on the project within Israel’s aircraft industry. In April, Israel Aerospace Industries (IAI) and Elbit Systems’ Cyclone subsidiary confirmed that they had completed initial design studies on different fuel tank designs. IAI studied a conformal fuel tank design, while Cyclone examined a design for a 600-gal. external fuel tank. The latter would likely help preserve the F-35I’s stealthy profile on radar.

Lockheed confirms that it is now engaged in a study about the option for a 600-gal. fuel tank and a wing pylon that can be jettisoned. The tank is designed to be integrated on the inboard stations—3 and 9—on each wing, the company says. Although the pilot can restore the F-35A’s stealth signature to radar by jettisoning the tank and pylon, it is not clear how the radar cross-section is affected with the equipment attached to the wing.

Given that the 18,500-lb. internal fuel capacity of the F-35A is equivalent to 3,000 gal., adding two 600-gal. external tanks on an F-35A would raise overall fuel volume onboard to 4,200 gal., or 25,700 lb. That still falls short of the 35,500-lb. capacity for an F-15E configured for a ferry flight but should dramatically increase the single-engine fighter’s endurance.

“While exact ranges depend on mission profiles, our studies show a significant increase in both range and loiter time—or mission persistence,” a Lockheed spokesman says.

So far, the company has completed feasibility studies and conducted initial analysis, as well as early design of the range-extension upgrades. The industry-funded work was done in advance of an approved customer requirement, but Lockheed plans to present the range extension as a candidate upgrade through the Continuous Capability, Development and Delivery framework for the F-35’s follow-on modernization program, also known as Block 4.

The remaining work required includes detailed design and qualification of the fuel tank and pylon, as well as software integration, flight testing and airworthiness certification, Lockheed says.
ORAC is online now  
Old 21st Jun 2019, 14:13
  #11919 (permalink)  
 
Join Date: Aug 2007
Location: virginia, USA
Age: 56
Posts: 1,060
Received 15 Likes on 10 Posts
Wow, 600 gallon tank on each side, that's the same size as the big F-4 Phantom centerline tank.

I can think of a few scenarios where Israel and other users might find these handy.

As for the "it is not clear how the radar cross-section is affected with the equipment attached to the wing..." I have an idea.
sandiego89 is offline  
Old 21st Jun 2019, 15:11
  #11920 (permalink)  
Ecce Homo! Loquitur...
 
Join Date: Jul 2000
Location: Peripatetic
Posts: 17,228
Received 1,496 Likes on 678 Posts
About the same size as the Tornado 2250L underwing tanks.


ORAC is online now  

Thread Tools
Search this Thread

Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

Copyright © 2024 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.