Go Back  PPRuNe Forums > Aircrew Forums > Military Aviation
Reload this Page >

Future Carrier (Including Costs)

Military Aviation A forum for the professionals who fly military hardware. Also for the backroom boys and girls who support the flying and maintain the equipment, and without whom nothing would ever leave the ground. All armies, navies and air forces of the world equally welcome here.

Future Carrier (Including Costs)

Old 1st Nov 2019, 15:19
  #5681 (permalink)  
 
Join Date: Dec 2018
Location: Dundee
Posts: 2
Likes: 0
Received 0 Likes on 0 Posts
Apparently reports

of the Russian navy hunting Big Liz down.

X10 submerged assets on their way from Kola..
weemonkey is offline  
Old 1st Nov 2019, 16:51
  #5682 (permalink)  
 
Join Date: Dec 2002
Location: UK
Posts: 2,451
Likes: 0
Received 9 Likes on 5 Posts
Engines, thanks for the education.

Re U.K. all F35B, land and sea use, presumably this should enable the aircraft to ‘ski’ off road bridges and ‘land’ in the hole in the woods if future land strategy requires. i.e. a more flexible aircraft against increased wt, aka Harrier.

Also we tend the think that more weapons = more weight, which could be changing with new lighter technologies, except someone requires more range, more weapons, more … , or even a mini stealth AEW.
safetypee is offline  
Old 1st Nov 2019, 17:03
  #5683 (permalink)  
Ecce Homo! Loquitur...
 
Join Date: Jul 2000
Location: Peripatetic
Posts: 17,229
Received 1,498 Likes on 678 Posts
ORAC is offline  
Old 1st Nov 2019, 17:16
  #5684 (permalink)  
Ecce Homo! Loquitur...
 
Join Date: Jul 2000
Location: Peripatetic
Posts: 17,229
Received 1,498 Likes on 678 Posts
Engines, you omitted the other main drawback of that fat wing on the F-35C, the much slower acceleration.

The acceleration of the F-35C from M0.8 to M1.2M is 27 seconds slower than the B and 35 seconds slower than the A; and acceleration up to M1.6 consumes almost all internal fuel.....
ORAC is offline  
Old 1st Nov 2019, 17:45
  #5685 (permalink)  
 
Join Date: Dec 2006
Location: UK
Posts: 799
Likes: 0
Received 0 Likes on 0 Posts
ORAC,

Breaking my 'go quiet' rule only to say thank you. Yes, you are quite right, the F-35C is really a lot slower to go supersonic and it does burn fuel - bigger wings and tails will do that. (Curse those pesky laws of physics). Incidentally, as part of the 2004/5 weight reduction effort, I believe that LM were looking at removing some internal fuel tank capacity from the C, as it was showing a predicted range way above the KPP figures. I don't know if that went ahead, though. If they did, that would be quite an unusual design decision - but it shows how important the weight reduction programme was for all 3 variants, not just the B.

One lesson I've learned on my journey through aircraft engineering is this - getting aircraft to be able to do 'cat and trap' operations is way, way harder than the USN makes it look. Getting aircraft to do it and be operationally effective is even harder than that. Being operationally effective at sea at night in bad weather is even harder than THAT.

Best Regards as ever to all those doing just that right now.

Engines
Engines is offline  
Old 1st Nov 2019, 18:59
  #5686 (permalink)  
Thread Starter
 
Join Date: Feb 2002
Location: Devon
Posts: 2,808
Received 19 Likes on 15 Posts
Just a few quick points:

tdracer/Wondering

The UK intends to operate a joint RN/RAF force, this is not tied exclusively to the carriers. For conventional CV aircraft that would mean a high training burden to keep everyone carrier qualified. In 1982 1 Sqn RAF were able to embark Harrier GR3 aboard HMS Hermes because they are V/STOL aircraft, and because the ship was up to speed with operating jets.

Additional catapults and arresting gear mean more expensive equipment to be integrated and maintained, and more manpower. The SDSR 10 cuts slashed naval manpower without much thought, Cameron wimped out of increasing RN (and RAF) manpower in 2015.

Lastly, STOVL carrier operations are less sensitive to whether than old style CV ones. The QEC design is smaller than the US carrier and would have not had the same operating limits with F-35C, however with F-35B they probably can.

Easy Street

One possible NATO scenario puts a UK carrier based ASW task group (with NATO frigates and SSKs) in the Eastern Atlantic and/or GIUK gap to conduct task group ASW (Merlins with dipping sonar, frigates (and destroyers) with towed array (and hull mounted) sonar and submarines as part of the task group. Meanwhile the F-35B can counter Bears, Backfires, and so on.

See: Fire and Ice - A New Maritime Strategy for NATO's Northern Flank

The UK has committed a carrier capability to NATO, and this seems similar to the Cold War and the roles of CVS/Sea Harrier/Sea King.
WE Branch Fanatic is offline  
Old 1st Nov 2019, 19:35
  #5687 (permalink)  
 
Join Date: Aug 2009
Location: Derbyshire
Posts: 415
Likes: 0
Received 82 Likes on 21 Posts
Engines

Hi Engines - you seem to know what is going on in this programme - (program for our cousins!)

I emerge from hibernation because you have offered information that was unknown to me before.

I had previously believed that we (the UK) should have bought the C and put launch and arrester gear on the QE/PoW. That way we could have operated from land or afloat without major penalty.

The B/STOVL version was, in my opinion, a Harrier/Invincible legacy that was inappropriate for current requirements.

The Harrier austere landing site concept was brilliant and worked well in its time, but it required essential and substantial support from the Royal Engineers, Signals folk and many others. That infrastructure worked really well in Germany in the 70's/80's but it has now all gone. I know the USMC position and fully understand and support their need for the B and its austere potential, but I am not sure that we either need or could afford that option.

So if the value of STOVL is now just to allow aircraft to operate from QE/PoW, then perhaps the C might have been better.

But the variations suggested about the C might make me think that my views that we should have bought the C rather than the B are wrong. Interoperability with the USN and French notwithstanding.

It all doesn't really matter now as things are well down the track, but it would make me feel better to know that my prejudices are wrong and that our esteemed politicians and their advisers were right all the time!

I would much appreciate your views.
ex-fast-jets is offline  
Old 2nd Nov 2019, 00:53
  #5688 (permalink)  
 
Join Date: Apr 2009
Location: Wherever it is this month
Posts: 1,779
Received 75 Likes on 34 Posts
Originally Posted by WE Branch Fanatic
One possible NATO scenario puts a UK carrier based ASW task group (with NATO frigates and SSKs) in the Eastern Atlantic and/or GIUK gap to conduct task group ASW (Merlins with dipping sonar, frigates (and destroyers) with towed array (and hull mounted) sonar and submarines as part of the task group. Meanwhile the F-35B can counter Bears, Backfires, and so on.

The UK has committed a carrier capability to NATO, and this seems similar to the Cold War and the roles of CVS/Sea Harrier/Sea King.
Yes, I know that this is now the favoured narrative among carrier supporters, hence my comment about 'blue water ops'. And it's absolutely not what the Government had in mind when it agreed to invest billions in the carrier strike concept. Sure, the strategic picture has changed since the late 2000s and CONOPS have to evolve. But the idea of committing the UK's 5th gen effort to countering Bears and Backfires instead of exploiting its capability to operate in defended airspace is an odd one.

You need speed, good range and endurance, large numbers of air-to-air weapons, early warning and ideally tanker support to make a good fist of the air defence role. None of those are strong suits of the QEC air wing. In the NATO context, it has to be said that the USN air wings are much better-suited to it.

I'm ready for the 'party line' response to that, too: that the UK carrier group's availability lets the US do something else with one of theirs. But one of the aims of NATO is famously to 'keep the Americans in' and offering them an off-ramp seems an odd way of going about that. Besides, you only have to follow the news to wonder whether the 'something else' would always be aligned to British interests.

It's not a compelling narrative, IMHO. If there is a SDSR next year (which looks all the more likely now that we'll have a new government as the 5-year point since SDSR15 approaches) then there will be some interesting debate about how to beef up QEC group capabilities so that it can do more under Article V than simply relieve the US of an Atlantic commitment. Where would the cuts fall to make that happen? Or might it be decided that QEC will stay ocean-bound in any Article V plans, leading to announcement of the first UK A-model acquisitions? An interesting year beckons, for sure.

Last edited by Easy Street; 2nd Nov 2019 at 01:11.
Easy Street is offline  
Old 2nd Nov 2019, 05:53
  #5689 (permalink)  
Ecce Homo! Loquitur...
 
Join Date: Jul 2000
Location: Peripatetic
Posts: 17,229
Received 1,498 Likes on 678 Posts
The Role of the Invincible class in the Cold War was as part of the outer screen for a CBG with the Shar able to launch and “hack the shad” as Bear-Ds Tracking the fleet slipped in and out of long range radar cover outside CAP range. Not a role the F-35B will be suitable or able to perform from the centre of its own CBG, and far less capable at the CAP role than the F-14/F-18s if the era.

The threat itself also having been retired and replaced by satellite surveillance. Regardless I cannot see the RN being willing to use the QE as a sacrificial goat to protect a USN carrier.
ORAC is offline  
Old 2nd Nov 2019, 09:58
  #5690 (permalink)  
Thread Starter
 
Join Date: Feb 2002
Location: Devon
Posts: 2,808
Received 19 Likes on 15 Posts
The primary role of the Invincible class was to operate nine or so ASW Sea Kings for task group ASW in the Atlantic and GIUK gap. The Sea Harrier came later (and the anti Bear role existed because the Bear provided long range targeting for Soviet submarine launched missiles) - and the AEW Sea King after that. I have no idea what the party line is today - but I assume were are still in the business of maritime task groups, and crisis response shipping -and they are major exercises planned such as DEFENDER 2020.

The carrier will not always have to have as many jets aboard as possible. This was one of the reasons for acquiring the B, as the C version would mean constant deck landing training. For some reason people overlook this, like they ignore the manpower needed for cats and traps..

This looks like a tooled up jet to me:


Last edited by WE Branch Fanatic; 2nd Nov 2019 at 16:51.
WE Branch Fanatic is offline  
Old 2nd Nov 2019, 14:15
  #5691 (permalink)  
 
Join Date: Jan 2004
Location: Far West Wessex
Posts: 2,577
Received 4 Likes on 2 Posts
The F135 STOVL propulsion system weighs almost 4,000 lb more than the CTOL version. I would guess that this number includes only the bits for which P&W as prime is responsible, which would not include doors and actuators.

The difference in OEW is less, as Engines correctly points out, but that is due to the omission of the gun and its feed system and an aggressively lightened airframe.

As for the F-35C: It was the last version to close and the wing area and OEW continued to grow through 2006. 35 per cent bigger wing than a Super Hornet, because it lacks an effective high-lift system. I don't think it's a great example of a CV penalty at work.

On the Rafale commonality: I don't have any parts-count numbers, but I do know that Dassault employed and improved CATIA with the aim of getting the best balance between eliminating "scar weight" on the CTOL and maintaining commonality. Some of this involved the idea of "cousin parts" - differing in weight and strength but fitting together in the same way - and the idea of concentrating the difference in the smallest possible number of parts. This was a JSF goal but I think a lot of it went out of the window in the Great Weight Panic.

LowObservable is offline  
Old 2nd Nov 2019, 15:21
  #5692 (permalink)  
 
Join Date: Dec 2006
Location: UK
Posts: 799
Likes: 0
Received 0 Likes on 0 Posts
LO,

Sorry, I think I could helpfully respond here:

The empty weights I quoted were actual 'as weighed' from the 2016 OT&E report. Once again, for clarity, all three variants (that's A, B and C) have 'aggressively lightened airframes'.

Yes, the B and C don't have an internal gun, but the point I was trying to get over (and clearly not doing very well ) is that the B and C both have substantial 'penalty weights' for ship operation. (I suppose I could make the argument that the A model carries a penalty weight for having to have a gun - I believe that it was the only variant for which an internal gun was specified in the System Requirement Document). The B and C also lack the heavy boom refuelling receptacle that the USAF demanded for the A. Apples and oranges and all that....

LO is correct that the C was the last variant to be designed, but I'm not sure that this is relevant to the weight issues. For clarity, the original 'batting order' for the programme was A, then B, then C. Once the weight problem was realised around 2004, the weight reduction effort was focussed first on the B, as that was the variant most severely affected. From then on, the batting order ran B, A, then C. Almost all of the weight saving measures developed for the B were moved over to both the A and the C. What is true is that the C was able to exploit most of the B's weight saving changes earlier in its design cycle than the A, so there was less rework than on the A. One big measure it couldn't adopt, though, were the reduced size tail fins - the C had to keep its big fins for the low speed approach.

Yes, the F-35C does lack the F/A-18's slotted flaps, but that was driven by LO issues and known at the outset when the wing was sized. I have to gently disagree and say that, for my money at least, the F-35C's design is a perfectly valid example of a 'CV penalty'. I had some involvement in some of the CV specific design work and I can confirm that deck ops exacted a significant penalty in weight. The main thing I took away was that the DOD's selection of carrier approach speed (Vpa) as a Key Performance Parameter (KPP) was absolutely on the nail - it was the parameter that drove much of the C's design.

LM used CATIA, not always as well as other companies I worked with, but they got better as time went on. Yes, they wanted to limit the number of differences between variants, but during the weight reduction effort they had to make more compromises than they originally wanted. In some cases, it was found that 'commonality' was imposing severe weight penalties, and variant specific changes were essential. As to 'cousin parts', LM used the idea frequently, and had been for some time - McDonnell Douglas were certainly using them in the 1970s and 80s. As I've posted a number of times, LM made a poor job of the airframe design and, unforgivably for any combat aircraft but especially for a power lift aircraft, failed to keep control of airframe weight. In my view (and just opinion) it cost the programme at least two years and a ton of money.

I hope these posts help people understand that getting the F-35 programme across the line has been a massively difficult undertaking. Yes, one can pillory LM for not doing better. One can also recognise that they (and NG and BAES) have made some towering technical achievements along the way to get the programme to where it is now. And those achievements rest on sheer hard work and brilliance from thousands of dedicated people.

Best regards as ever to my friends at LM and BAES,

Engines

PS: and now I really will go quiet for a bit.
Engines is offline  
Old 2nd Nov 2019, 21:07
  #5693 (permalink)  
 
Join Date: Aug 2012
Location: Scotland
Age: 54
Posts: 278
Received 72 Likes on 21 Posts
Originally Posted by Engines
PS: and now I really will go quiet for a bit.
No, please don't do that!

Some of the technical aspects & more so the reasoning behind them make for vey interesting reading.

Thrust Augmentation is offline  
Old 3rd Nov 2019, 17:38
  #5694 (permalink)  
Thread Starter
 
Join Date: Feb 2002
Location: Devon
Posts: 2,808
Received 19 Likes on 15 Posts
The second part of Chris Terrill's documentary about HMS Queen Elizabeth and last years WESTLANT 18 deployment is in BBC2 at 2000 GMT tonight. Last week focused a lot on the first F-35B landing and take off, but also mentioned the ASW role of the Merlin HM2.

I believe it is on BBC iPlayer too.

When the replacement for the Invincible class CVS (ASW carrier) was first studied in the nineties, it was apparent that larger carriers were needed. The 20 000 size of the Invincibles was a legacy of their origin as platforms for ASW in the NATO theatre, operating sufficient helicopters for constant dipping (sonar in water). It just so happened they making them just a little larger allowed a Harrier sized aircraft to be operated. This was useful as the Soviet submarines often carried missiles with guidance provided by Bears, so Harrier became Sea Harrier to 'hack the shad'. The addition of an AEW capability post Falklands meant that the jets could be used more effectively than standing constant CAP.

In the nineties, the small size of the CVS limited our ability to carry a meaningful number of jets, both Sea Harrier (primarily air defence) and Harrier GR7/9, plus the ASW and AEW helicopters. Post Cold War, the assumption was made that Cold War type missions such as ASW, fleet defence, protecting sea lines of communication and so on were things of the past, as we opted to fight campaigns in landlocked (or nearly landlocked), so the politicians, and public bought into the carriers = attack only type thinking.

F-35B was the only V/STOL successor to Sea Harrier/Harrier, and was intended to be capable of the full range of missions including Defensive Counter Air and Offensive Counter Air. Even without security and Geopolitical issues with Russia, it should have been clear that after Iraq and Afghanistan, the next conflict would most likely involve an adversary with naval and air capabilities such as submarines or MiGs.

Part of the problem (for the RN) is that no record was kept of why STOVL was the preferred option (cost of equipment, the training burden, manpower, and operating limits for smaller carriers in higher sea states) to inform the politicians, nor were the whole ship aspects of fixed wing flying properly articulated.
WE Branch Fanatic is offline  
Old 3rd Nov 2019, 20:47
  #5695 (permalink)  
 
Join Date: May 1999
Location: Quite near 'An aerodrome somewhere in England'
Posts: 26,783
Received 257 Likes on 103 Posts
The second part of Chris Terrill's documentary about HMS Queen Elizabeth and last years WESTLANT 18 deployment is on BBC2 at 2000 GMT tonight.
And very good it was too!
BEagle is offline  
Old 3rd Nov 2019, 20:48
  #5696 (permalink)  
 
Join Date: Jan 2004
Location: Far West Wessex
Posts: 2,577
Received 4 Likes on 2 Posts
Peace, Engines...

We seem to be mostly in factual agreement. The interesting thing is that discussing "penalties" or "scar weight" in the A/B/C context depends on which version is considered as the baseline - but thinking about it some more, this may be misleading, since none of the versions is the baseline.

The key to understanding the aerodynamic, structural and propulsion elements of the F-35 design is that no aircraft in history, that I can think of, has had such diverse and competing requirements imposed on it, along with a battery of non-negotiable constraints.

t was much more than what the late George Muellner described as "three versions differing only in how they took off and landed". CV requirements meant (eventually) quad tails and either a large wing, or the ability to accommodate two wing sizes. STOVL mandated a single large engine, located close to the CG, along with minimal OEW. Compatibility with different ships imposed limits on span and length. LO demanded large internal volume, translating into a rather broad body and an unusual relationship of net to gross wing area, and was unforgiving regarding changes to the mold line - all versions had to have the same wing sweep.

It would all have been hard enough, even without the USAF's willingness to die on the barricades to protect sustained 9g. For what it's worth, I don't think any of the designs submitted in 1996 would have done any better than the F-35. The engineers did their best, but there was no elegant solution to the problem enshrined in the JORD.
LowObservable is offline  
Old 3rd Nov 2019, 21:02
  #5697 (permalink)  
 
Join Date: Dec 2015
Location: Southampton
Posts: 125
Received 0 Likes on 0 Posts
Thanks for your reply Engines.
Tech Guy is offline  
Old 4th Nov 2019, 18:31
  #5698 (permalink)  
 
Join Date: Jan 2007
Location: Location: Location!
Posts: 2,295
Received 33 Likes on 25 Posts
Originally Posted by BEagle
And very good it was too!
Much enjoyed, although rather sad to see the tribute at the end in memory of Nimali Amaratunga-Brearley, the young civilian engineer seen earlier in the programme testing the flight deck coating.

Jack
Union Jack is offline  
Old 4th Nov 2019, 19:26
  #5699 (permalink)  
 
Join Date: Mar 2010
Location: Often in Jersey, but mainly in the past.
Age: 79
Posts: 7,786
Received 129 Likes on 58 Posts
Originally Posted by Union Jack
Much enjoyed, although rather sad to see the tribute at the end in memory of Nimali Amaratunga-Brearley, the young civilian engineer seen earlier in the programme testing the flight deck coating.

Jack
indeed a good episode, but a rather unpleasant shock during the credits that the lady had died. A quick search on google implies it may have been cancer - what a very sad event.
MPN11 is offline  
Old 4th Nov 2019, 19:36
  #5700 (permalink)  
 
Join Date: Apr 2010
Location: Herefordshire
Posts: 756
Received 507 Likes on 183 Posts
Originally Posted by Easy Street
Also the drag of the door is less than it would appear because suction causes the airflow to curve down into the fan rather than impinge directly on the door.
Graphically illustrated in last-night's programme by the unfortunate small bird that was sucked down into the lift fan.

Video Mixdown is online now  

Thread Tools
Search this Thread

Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

Copyright © 2024 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.